Abstract
In situ, quantitative infrared spectrometry has been used to measure the evolution of carbon dioxide during the photo-degradation of pigmented and unpigmented acrylic-emulsion paint films. It is demonstrated that the method permits a fast and convenient way of assessing the resistance of such paints to UV degradation. However, it is also shown that valid comparisons of paints prepared with different grades of titanium dioxide, but with the same acrylic emulsion, require careful selection and control of the experimental conditions. Thus, the relative importance of (a) direct photochemical oxidation of the binder and (b) indirect photo-catalysed oxidation (mediated by titanium dioxide) depend not only on the spectral distribution of the radiation source, particularly the output between 300 and 400 nm, but also on the humidity of the ambient atmosphere. The increased rate of oxidation with increased humidity is not unexpected, but the size of the effect is unexpectedly high. In addition, there is some carbon dioxide formation during irradiation of the paint film in nitrogen and further investigation of this phenomenon is in hand. For both pigmented and unpigmented films, the rate of carbon dioxide evolution is sensitive to the film thickness. The dependence of the oxidation rate on the thickness of clear, unpigmented films is consistent with the measured UV absorption. However, for pigmented films, this dependence extends over greater film thicknesses than predicted by a simple model based on paint film optics.
Similar content being viewed by others
References
W. F. Sullivan, Prog. In Organic Coatings 1(1972) 157.
Z. W. Wicks JR., F. N. Jones and S. P. Pappas, in “Organic Coatings, Science and Technology,” Vol. 2, “Applications, Properties and Performance,” (John Wiley, New York, 1994) Chap. 25.
R. B. Cundall, R. Rudham and M. S. Salim, J. Chem. Soc. Faraday I 72(1976) 1642.
T. A. Egerton and C. J. King, J. Oil. Col. Chem. Assoc. 62(1979) 386.
A. Mackor, T.P.M. Koster and L. Kui-wen, in Proceedings of 15th International Congress in Organic Coatings Science and Technology, edited by A. V. Patsis, (Technomics, Athens, 1989) p. 219.
E. M. Ceresa, L. Burlamacchi and M. Visca, J. Mater. Sci. 18(1983) 289.
J. H. Braun, J. Coatings Technol. 62(1990) 37.
G. Kaempf, W. Papenroth and R. Holm, J. Paint Technol. 46(1974) 56.
T. A. Egerton, 'Modification of Fine Powders by Inorganic Coatings' Kona 16(1998).
W. Hughes, in Proceedings of Xth FATIPEC Congress (Verlag Chemie GmbH, Weinheim, 1970) p. 67.
M. J. Hird, J. Coatings Technol. 48(1976) 75.
T. A. Egerton, Polymer Degradation Discussion Group, Tenth Symposium Manchester, September 1985.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Christensen, P.A., Dilks, A., Egerton, T.A. et al. Infrared spectroscopic evaluation of the photodegradation of paint Part I The UV degradation of acrylic films pigmented with titanium dioxide. Journal of Materials Science 34, 5689–5700 (1999). https://doi.org/10.1023/A:1004737630399
Issue Date:
DOI: https://doi.org/10.1023/A:1004737630399